Product ID:340 HP H/S POLY CATALYST, 340-HP, 340-HP
MSDS Date:01/01/1991
FSC:8010
NIIN:00N056193
MSDS Number: BWMZL

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE
SO EL MONTE, CA 91733
US

Emergency Phone: 818-444-9274

Info Phone: 818-444-9274

Preparer: RICHARD STEWART

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE - U.G.) (SARA

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10%

OSHA PEL 150 PPM; 200 STEL

ACGIH TLV: 150 PPM; 200 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

HEXANE, 1,6-DIISOCYANATO-; HEXAMETHYLENE DIISOCYANATE

CAS: 822-06-0

RTECS: MO1740000

Fraction By Weight: <0.002%

OSHA PEL N/K

ACGIH TLV: 0.005 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

0.93 LB/GAL

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: HDCH, FATG, WEARINESS,
NAUS, VOMIT, DIZZ, STUPOR, DROW, DISTURBED VISION, COUGH & UNCON.
SKIN: PRLNG CNTCT CAN CAUSE MOD IRRIT, DEFAT & DERM. ABSORPTION:
MOD IRRIT, DEFAT, DERM, DRY SKIN , RASH. EYES: CAN CAUSE SEV IRRIT,
REDNESS, TEARING & BLURRED VISION. INGEST: BREATH SMELLS OF SOLV,
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: IRRIT OF LIPS & MOUTH, GI IRRIT,
NAUS, DIARR, DROW, LOSS OF CONSCIOUSNESS, STATE OF SHOCK, WEAK &
RAPID PULSE, COLD-PALE COMPLEXION. CHRONIC: MAY PRDCE LIVER &
KIDNEY DMG, PERSISTENT COUGH, BRAIN DMG & MAY EVEN CAUSE DEATH.
OVEREXP HAS APPARENTLY BEEN FOUND TO CAUSE FOLLOWING EFTS IN LAB
ANIMALS: (SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER & KIDNEY DISORDERS.
ALLERGIC REACTIONS POSSIBLE.

First Aid:EYES: FLUSH W/PLENTY OF WATER FOR AT LEAST 15-30 MIN. GET
MEDICAL ATTENTION. SKIN: WASH EXPOSED AREA W/MILD SOAP & WATER FOR
15 MIN. REMOVE CONTAMINATED CLOTHING. INHAL: REMOVE TO FRESH AIR.
IF BREATH ING IS DIFFICULT, ADMINISTER OXYGEN. IFBREATHING HAS
STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION.
INGEST: DO NOT INDUCE VOMITING. KEEP VICTIM WARM & SEEK IMMEDIATE
MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:72.0F,22.2C
Lower Limits:1.7%
Upper Limits:7.6%
Extinguishing Media:FOAM, ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL,
WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPKS, ELEC EQUIP & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. DURING EMER CNDTNS, (SUPDAT)

Spill Release Procedures:FOLLOW INSTRUCTIONS TO PREVENT HEALTH HAZARDS.
ELIMINATE ALL SOURCES OF IGNITION, ABSORB LIQUIDS IN ABSORBENT
MATERIAL & PREVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AT ROOM TEMPERATURE AWAY FROM
HEAT SOURCES AND HAVE LIDS TIGHTLY CLOSED.
Other Precautions:CONTAINERS MAY BE HAZARDOUS WHEN EMPTIED. SINCE
EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUALS (VAPORS, LIQUID
AND/OR SOLIDS), ALL PRECAUTIONS GIVEN IN MSDS MUST BE OBSERVED.

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED,
NIOSH/MSHA APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF
ENVIRON CTL. OSHA REGS PERMIT OTHER NIOSH/MSHA APPRVD RESPS UNDER
SPECIFIED CNDTNS. (SEE SFTY EQU IP SUPPLIER). ENGINEERING OR
(SUPDAT)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL OR LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW THE TLVS.
Protective Gloves:POLYVINYL ALCOHOL COATED/POLYETHYLENE.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:PREVENT REPEATED OR PROLONGED SKIN CONTACT
W/GB PROTECTIVE HANDCREAM. WEAR IMPERVIOUS CLOTHING & CHEM
RESISTANT BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING THE REST
ROOM. SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EXPLO HAZ: OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE
IMMED APPARENT. OBTAIN MED ATTN. EFTS OF OVEREXP: LIVER ABNORM,
KIDNEY & LUNG DMG. ALSO HAS BEEN SUGGESTED AS CAUSE OF FOLLOWING
EFTS IN HUMANS:CARD & LIVER ABNORM, KIDNEY & LUNG DMG. RESP PROT:
ADMIN CTLS SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.

Boiling Pt:B.P. Text:260F,127C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.2 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NONSOLUBLE
Appearance and Odor:CLEAR THICK LIQUID; SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES.
Hazardous Decomposition Products:HAZARDOUS DECOMPOSITION MAY PRODUCE
CARBON DIOXIDE AND/OR CARBON MONOXIDE.

Waste Disposal Methods:RECYCLE LIQUIDS IF POSSIBLE. INCINERATE SOLIDS
IN ACCORDANCE WITH APPLICABLE FEDERAL, STATE & LOCAL REGULATIONS.
AS A LAST RESORT NEUTRALIZE & LANDFILL IN ACCORDANCE WITH LOCAL,
STATE & FEDERAL REGULA TIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.